pickd it up today, problems already!!!!

30-09-2009, 22:07

well as it says picked up the maverick today, 30 mins later on the way home, BANG!!!!! goes the gearbox breather, take it back, and just make it and they clean the breather out top up the gearbox and away we go again,

NOT A GOOD START IM THINKING!!!!!

thats been fine since, done 100miles after and all seems fine,BUT,

at tick over it idles a bit rough, bit like a taxi

, although as you pick speed up it clears, any ideas????

and also apparently the drivers side has a dry joint that just needs greasing? is that ok or should it need a new joint?

happy enough with it still just want to sort this tickover problem out, its had new plugs, leads, cap and rotor so im thinking crap in the jets maybe?
suggestions anyone?

thanks again for looking and reading, i do apprieciate it and thanks for any tips,
all the best,
craig

paulp · 30-09-2009, 22:18

do u think putting crap in the jets will help.

I know the last thing u need when you have problems is a smart arse.

You could have an air leak.

Someone will say its dangerous but spray WD40 over the pipes/ hoses gaskets of the injection system.

If the hunting or rough running stops on contact with the wd 40 you have found your air leak.

good luck gutted you had a bad start, stick with it the trucs are worth i, so is this site

paulp

Terranosaurus · 30-09-2009, 23:02

Dry joint on drivers side???? Is that creaking on full lock? If so its the steering stop sthat need greasing - non of the joints are greasable.

zippy656 · 01-10-2009, 05:40

Quote:

Originally Posted by Terranosaurus

Is that creaking on full lock? If so its the steering stop sthat need greasing .

that a job for my 12 year old. she loves to get under with a tub og grease

01-10-2009, 12:05

Quote:

Originally Posted by zippy656

that a job for my 12 year old. she loves to get under with a tub of grease

I cannot make a comment on that becuase she is 12.

zippy656 · 01-10-2009, 12:19

LOL.

what makes it worse is Ive got two 12 year olds!

clivvy · 01-10-2009, 19:42

bad start dude, i am the same, hadnt had mine long before the troubles began, its still off the road now! I also have an idle problem. It idles away, but if you listen, its not th eusual confident diesel sound, it goes up and down slightly, then randomly revs itself (rv counter stays where it is at 500 rpm) and I have no idea why! driving it was ok before the starter went and CKP sensor, so I shoudl fit a new ckp this weekend and maybe change fuel filter and se if it runs any better, buti think mine idles too low.

good luck, they are really nice trucks when they are working, i miss driving mine!

01-10-2009, 21:49

Quote:

Originally Posted by paulp

do u think putting crap in the jets will help.

I know the last thing u need when you have problems is a smart arse.

You could have an air leak.

Someone will say its dangerous but spray WD40 over the pipes/ hoses gaskets of the injection system.

If the hunting or rough running stops on contact with the wd 40 you have found your air leak.

good luck gutted you had a bad start, stick with it the trucs are worth i, so is this site

paulp

done the above and with a little help from a friend, we think the inlet manifold gasket is leaking, blasted wd40 all over that side of the engine and it ticks over all nice till the wd's burnt off, so next tuesday its going in to be sorted, HOPEFULLY

really nice thing to drive though, although being a petrol, not the most practcal of things i must admit, but atleast it will pull my caravan

thanks for all the advice and tips and i will let you know how it pans out,
all the best for now,
craig

makeitfit · 01-10-2009, 21:55

Stick some LPG up it

That'll save you huge amounts of bucks

Even more if you er use some gas from red bottles

30-09-2009, 22:07	#1
craig1976 Guest Posts: n/a	pickd it up today, problems already!!!! well as it says picked up the maverick today, 30 mins later on the way home, BANG!!!!! goes the gearbox breather, take it back, and just make it and they clean the breather out top up the gearbox and away we go again, NOT A GOOD START IM THINKING!!!!! thats been fine since, done 100miles after and all seems fine,BUT, at tick over it idles a bit rough, bit like a taxi, although as you pick speed up it clears, any ideas???? and also apparently the drivers side has a dry joint that just needs greasing? is that ok or should it need a new joint? happy enough with it still just want to sort this tickover problem out, its had new plugs, leads, cap and rotor so im thinking crap in the jets maybe? suggestions anyone? thanks again for looking and reading, i do apprieciate it and thanks for any tips, all the best, craig

30-09-2009, 22:18	#2
paulp Senior Member Join Date: Apr 2009 Location: essex Vehicle: nissan mistral 27td Posts: 1,043	sorry do u think putting crap in the jets will help. I know the last thing u need when you have problems is a smart arse. You could have an air leak. Someone will say its dangerous but spray WD40 over the pipes/ hoses gaskets of the injection system. If the hunting or rough running stops on contact with the wd 40 you have found your air leak. good luck gutted you had a bad start, stick with it the trucs are worth i, so is this site paulp

30-09-2009, 23:02	#3
Terranosaurus Senior Member Join Date: Aug 2006 Location: YORKSHIRE Vehicle: 2001 2.7 TDi T2 SWB Posts: 4,077	Dry joint on drivers side???? Is that creaking on full lock? If so its the steering stop sthat need greasing - non of the joints are greasable.

01-10-2009, 12:19	#6
zippy656 Senior Member Join Date: Aug 2008 Location: Devizes Wiltshire Vehicle: Nissan Note Ntec 1.5 Posts: 14,138	LOL. what makes it worse is Ive got two 12 year olds!

01-10-2009, 19:42	#7
clivvy Senior Member Join Date: Mar 2009 Location: Huddersfield Vehicle: Terrano 03 LWB Posts: 6,947	bad start dude, i am the same, hadnt had mine long before the troubles began, its still off the road now! I also have an idle problem. It idles away, but if you listen, its not th eusual confident diesel sound, it goes up and down slightly, then randomly revs itself (rv counter stays where it is at 500 rpm) and I have no idea why! driving it was ok before the starter went and CKP sensor, so I shoudl fit a new ckp this weekend and maybe change fuel filter and se if it runs any better, buti think mine idles too low. good luck, they are really nice trucks when they are working, i miss driving mine!

01-10-2009, 21:55	#9
makeitfit Senior Member Join Date: Apr 2008 Location: on the beach WEST WALES Vehicle: Maverick TDi BLACK mmm Posts: 15,136	Stick some LPG up it That'll save you huge amounts of bucks Even more if you er use some gas from red bottles