Automatic cutting out????????

Martabibaz · 04-04-2022, 19:25

Hiya guys.
New on here, been living in spain for 15 yrs.
I have a terrano 'll 99 which I've looked after for over 10 yrs. I've owned it for 3 yrs.
My issue is, got given fuel which was in a dirty can( didn't look at it was pitch black.)
Created a shite storm of issues where my fuel went black.
Cleaned out fuel tank, changed filter fitted inline filter. Cleaned out little gauze filter in top of pump. Changed rubber hoses from filter.
But it still cuts out when I'm driving normally after 15-20 mins, which is strange for an auto.
If I try to start it straight away I get clouds of black smoke, normally 10+ times trying to start. But now I've noticed if I leave it with ignition off for a minute or more it starts no problem.
I do hope someone can help me.
Cheers.

solarman216 · 04-04-2022, 22:08

Hi and welcome, I would say the muck has got into the pump, on the front next to the fuel inlet is a pressure regulating valve, it is a special two sided 10mm flat Bosch fitment, you need to make up something to fit and remove it, you will need to remove the inlet fitting first, once out with a blunt screwdriver or similar gently push the plunger, it must go in and out smoothly with absolutely no sign of sticking, if OK check the quality of the fuel in that part of the pump a syringe with a short bit of pipe will do, if there is any sign of dirt your pump will need to be repaired, otherwise refit the pressure valve, next remove the rear pipe and screw the banjo back in now operate the primer pump on the filter, a fine jet of fuel should spray out, other than that I would change the filter again and cut it open, if you have caught the fuel bug you will need to heavily dose the system to kill it, Rick

Martabibaz · 06-04-2022, 14:16

Cheers Rick.
I have removed the fitting at the back of the pump a couple of times now. And the little gauze filter is partially blocked.
Can I leave this fitting out and pump fuel through from filter to see what comes out. Cheers

solarman216 · 06-04-2022, 20:18

You can but do not try to run it like that as there will be no pressure regulation, and was the orifice clear in the banjo bolt, also what about the regulator valve on the front this is most important, Rick

04-04-2022, 19:25	#1
Martabibaz Junior Member Join Date: Apr 2022 Location: Spain Vehicle: terrano 'll 2.7tdi Posts: 2	Automatic cutting out???????? Hiya guys. New on here, been living in spain for 15 yrs. I have a terrano 'll 99 which I've looked after for over 10 yrs. I've owned it for 3 yrs. My issue is, got given fuel which was in a dirty can( didn't look at it was pitch black.) Created a shite storm of issues where my fuel went black. Cleaned out fuel tank, changed filter fitted inline filter. Cleaned out little gauze filter in top of pump. Changed rubber hoses from filter. But it still cuts out when I'm driving normally after 15-20 mins, which is strange for an auto. If I try to start it straight away I get clouds of black smoke, normally 10+ times trying to start. But now I've noticed if I leave it with ignition off for a minute or more it starts no problem. I do hope someone can help me. Cheers.

04-04-2022, 22:08	#2
solarman216 Off road maniac Join Date: Dec 2009 Location: Bexhill on Sea Vehicle: Y60 Patrol Me, 3 ltr Mrs Posts: 17,430	Hi and welcome, I would say the muck has got into the pump, on the front next to the fuel inlet is a pressure regulating valve, it is a special two sided 10mm flat Bosch fitment, you need to make up something to fit and remove it, you will need to remove the inlet fitting first, once out with a blunt screwdriver or similar gently push the plunger, it must go in and out smoothly with absolutely no sign of sticking, if OK check the quality of the fuel in that part of the pump a syringe with a short bit of pipe will do, if there is any sign of dirt your pump will need to be repaired, otherwise refit the pressure valve, next remove the rear pipe and screw the banjo back in now operate the primer pump on the filter, a fine jet of fuel should spray out, other than that I would change the filter again and cut it open, if you have caught the fuel bug you will need to heavily dose the system to kill it, Rick __________________ Ex banger racer now off road maniac Lokka on the front with manual hubs Diff lock on rear 3 inch SS straight through exhaust Manly winch bumper with 13000 lb winch 10 spike ground anchor, with multiple straps and blocks Super strong body cills capped with scaffold pole 20% stronger springs all round aggressive off road tyres on wheels so just swap. Aim to get stuck and be completely self sufficient in extraction, love getting muddy, 2ft deep is good but rare.

06-04-2022, 20:18	#4
solarman216 Off road maniac Join Date: Dec 2009 Location: Bexhill on Sea Vehicle: Y60 Patrol Me, 3 ltr Mrs Posts: 17,430	You can but do not try to run it like that as there will be no pressure regulation, and was the orifice clear in the banjo bolt, also what about the regulator valve on the front this is most important, Rick __________________ Ex banger racer now off road maniac Lokka on the front with manual hubs Diff lock on rear 3 inch SS straight through exhaust Manly winch bumper with 13000 lb winch 10 spike ground anchor, with multiple straps and blocks Super strong body cills capped with scaffold pole 20% stronger springs all round aggressive off road tyres on wheels so just swap. Aim to get stuck and be completely self sufficient in extraction, love getting muddy, 2ft deep is good but rare.

06-04-2022, 14:16	#3
Martabibaz Junior Member Join Date: Apr 2022 Location: Spain Vehicle: terrano 'll 2.7tdi Posts: 2	Cheers Rick. I have removed the fitting at the back of the pump a couple of times now. And the little gauze filter is partially blocked. Can I leave this fitting out and pump fuel through from filter to see what comes out. Cheers