Diesel pump?

Jems Terrano · 13-04-2021, 12:57

Hello

I've posted on the forum before but I cant put this subject where it needs to be. Might be because I've not been active for a little while 😃

I've just got my self a T2 3.0 version this time but its doesn't start. When I looked to getting this I was told that the fuel pump is at fault.

I've done all the electrical tests, I've got power to the pump and I've got a good earth all over the engine. I can prime the pump but on cranking I'm not getting diesel coming out.
(I've cracked a fuel pipe off from the pump)

My next job I was thinking is doing wiring tests from the fuel pump plug to the ECU plug and make sure those are ok. Also I need to check that the solenoid is getting power to command the pump?

Or it's going to be a case of making a start stripping the front of the engine down to make sure the cogs are turning on the pump?

Or worst case scenario Should I just admit that I'm going to need a fuel pump? And if so would anyone know of any for sale or if there are any diesel specialists to re con my pump?

Im based on orpington, kent. South east.

Thank you in advance.

Jem

panelbeater · 13-04-2021, 17:14

the 3l does usually not start if fuel is getting to ip,its most likley the box on the top of the pump thats got a fault in it.i have read about this a few times in the past and there is a couple of places that can repair the control module.you need to take pump off and send it to them.vary realy its the mechanical parts that go wrong only the control module.do some research on line to help you.

panelbeater · 13-04-2021, 17:51

try looking at www.autonorma for ip44,all carry a years gtee after rebuild.several ip44 shown so really need your ip number.very releasable prices for a tested rebuilt ip.

Jems Terrano · 13-04-2021, 19:58

Hello

Thank you for the advice, definitely something else for me to research Into now.

And funny enough after putting the post up I found that website autonorma, I will also look into this.

Thank you again.

panelbeater · 13-04-2021, 21:23

there is a kit out there from bosch for the electronic box about 150 but says needs to be fitted by a pump engineer.

13-04-2021, 12:57	#1
Jems Terrano Junior Member Join Date: Jan 2020 Location: Kent, South East. Vehicle: Terrano 2 Posts: 5	Diesel pump? Hello I've posted on the forum before but I cant put this subject where it needs to be. Might be because I've not been active for a little while 😃 I've just got my self a T2 3.0 version this time but its doesn't start. When I looked to getting this I was told that the fuel pump is at fault. I've done all the electrical tests, I've got power to the pump and I've got a good earth all over the engine. I can prime the pump but on cranking I'm not getting diesel coming out. (I've cracked a fuel pipe off from the pump) My next job I was thinking is doing wiring tests from the fuel pump plug to the ECU plug and make sure those are ok. Also I need to check that the solenoid is getting power to command the pump? Or it's going to be a case of making a start stripping the front of the engine down to make sure the cogs are turning on the pump? Or worst case scenario Should I just admit that I'm going to need a fuel pump? And if so would anyone know of any for sale or if there are any diesel specialists to re con my pump? Im based on orpington, kent. South east. Thank you in advance. Jem

13-04-2021, 17:14	#2
panelbeater Senior Member Join Date: Dec 2012 Location: clacton on sea essex Vehicle: nissan terrano 2 2.7 tdi Posts: 1,638	the 3l does usually not start if fuel is getting to ip,its most likley the box on the top of the pump thats got a fault in it.i have read about this a few times in the past and there is a couple of places that can repair the control module.you need to take pump off and send it to them.vary realy its the mechanical parts that go wrong only the control module.do some research on line to help you.

13-04-2021, 17:51	#3
panelbeater Senior Member Join Date: Dec 2012 Location: clacton on sea essex Vehicle: nissan terrano 2 2.7 tdi Posts: 1,638	try looking at www.autonorma for ip44,all carry a years gtee after rebuild.several ip44 shown so really need your ip number.very releasable prices for a tested rebuilt ip.

13-04-2021, 19:58	#4
Jems Terrano Junior Member Join Date: Jan 2020 Location: Kent, South East. Vehicle: Terrano 2 Posts: 5	Hello Thank you for the advice, definitely something else for me to research Into now. And funny enough after putting the post up I found that website autonorma, I will also look into this. Thank you again.

13-04-2021, 21:23	#5
panelbeater Senior Member Join Date: Dec 2012 Location: clacton on sea essex Vehicle: nissan terrano 2 2.7 tdi Posts: 1,638	there is a kit out there from bosch for the electronic box about 150 but says needs to be fitted by a pump engineer.