I'm new to these Navara's.

mark666 · 30-11-2016, 14:36

I have a 2009 Navara Sport X and I have noticed during the cold weather that the left side of the heater isn't getting warm at any level or setting.
I wasted £100 taking it to Nissan for them to tell me that there is no fault on their scanner and it must be in the heater.
Is there an easy way to get at the temperature control flaps so I can see if they are seized or might it be something else.
Thanks in advance, Mark.

Monaro Pete · 30-11-2016, 16:46

Welcome along

I'd say your heater matrix needs flushing through.
MG ZT's suffer with exactly the same fault.
The bottom half of the matrix heats the passenger side & the top half the drivers side.
All the silt & sludge sits in the bottom of the matrix.
Try washing it through with the hose pipe & see what comes out. Try the heater again. If this helps a little or not at all. Buy some decent dish washer tablets & dissolve a couple in hot water & pour the contents into the pipe feeding the matrix until it comes through the outlet side. leave it to stand for as long as you can (I let mine stand for around 12 hours over night).
Flush through with the hose pipe again & this should have cleared all the crap.

macabethiel · 30-11-2016, 21:38

Quote:

Originally Posted by mark666

I have a 2009 Navara Sport X and I have noticed during the cold weather that the left side of the heater isn't getting warm at any level or setting.
I wasted £100 taking it to Nissan for them to tell me that there is no fault on their scanner and it must be in the heater.
Is there an easy way to get at the temperature control flaps so I can see if they are seized or might it be something else.
Thanks in advance, Mark.

Gee that's a bit steep £100 and they did not find the actual fault !

solarman216 · 30-11-2016, 21:43

Welcome mate I cannot helpon Navara's but monaro pete's tip spunds on the ball, Rick

zippy656 · 30-11-2016, 21:51

Welcome

I've no idea about the heater :-)

macabethiel · 01-12-2016, 00:50

Quote:

Originally Posted by mark666

I have a 2009 Navara Sport X and I have noticed during the cold weather that the left side of the heater isn't getting warm at any level or setting.
I wasted £100 taking it to Nissan for them to tell me that there is no fault on their scanner and it must be in the heater.
Is there an easy way to get at the temperature control flaps so I can see if they are seized or might it be something else.
Thanks in advance, Mark.

Did they rule out the Thermostat then ?

30-11-2016, 14:36	#1
mark666 Junior Member Join Date: Nov 2016 Location: Avon Vehicle: Navara Sport X Posts: 1	I'm new to these Navara's. I have a 2009 Navara Sport X and I have noticed during the cold weather that the left side of the heater isn't getting warm at any level or setting. I wasted £100 taking it to Nissan for them to tell me that there is no fault on their scanner and it must be in the heater. Is there an easy way to get at the temperature control flaps so I can see if they are seized or might it be something else. Thanks in advance, Mark.

30-11-2016, 21:43	#4
solarman216 Off road maniac Join Date: Dec 2009 Location: Bexhill on Sea Vehicle: Y60 Patrol Me, 3 ltr Mrs Posts: 17,427	Welcome mate I cannot helpon Navara's but monaro pete's tip spunds on the ball, Rick __________________ Ex banger racer now off road maniac Lokka on the front with manual hubs Diff lock on rear 3 inch SS straight through exhaust Manly winch bumper with 13000 lb winch 10 spike ground anchor, with multiple straps and blocks Super strong body cills capped with scaffold pole 20% stronger springs all round aggressive off road tyres on wheels so just swap. Aim to get stuck and be completely self sufficient in extraction, love getting muddy, 2ft deep is good but rare.

30-11-2016, 16:46	#2
Monaro Pete Senior Member Join Date: Apr 2016 Location: Nr J28 M1 Vehicle: 03 Terrano 2.7 TDi Posts: 995	Welcome along I'd say your heater matrix needs flushing through. MG ZT's suffer with exactly the same fault. The bottom half of the matrix heats the passenger side & the top half the drivers side. All the silt & sludge sits in the bottom of the matrix. Try washing it through with the hose pipe & see what comes out. Try the heater again. If this helps a little or not at all. Buy some decent dish washer tablets & dissolve a couple in hot water & pour the contents into the pipe feeding the matrix until it comes through the outlet side. leave it to stand for as long as you can (I let mine stand for around 12 hours over night). Flush through with the hose pipe again & this should have cleared all the crap.

30-11-2016, 21:51	#5
zippy656 Senior Member Join Date: Aug 2008 Location: Devizes Wiltshire Vehicle: Nissan Note Ntec 1.5 Posts: 14,137	Welcome I've no idea about the heater :-)