Advice Needed - Page 2

solarman216 · 07-09-2014, 19:15

filler caps have not had vents for years the tank fumes are redirected back into the engine to be burnt often through a charcoal filter, Rick

AlexD333 · 07-09-2014, 19:20

All be it brief, I have quickly skipped through this and lots of talk about vents for fuel, I have to leave my fuel cap open a smidge otherwise it makes a vacuum

HISSSSS when you open it

solarman216 · 07-09-2014, 19:31

Quote:

Originally Posted by spautoparts

do you know what the internal diameter is for the pipe and what length for a lwb?

yours being a 2001 will be the same as Alex, now I am only familiar up to 2000 so perhaps another member with a later car can verify, but the one I did was 8mm flow and 6mm return, bores but I used 8mm for both asit is what I had, I kept the rubber joints at the tank end and used a fitting to go into the new pipe and existing rubber, the same at the engine end, flow I joined onto the rubber under the brake servo, and similar to the return from the pump, no point in doing the pipe across the back of the engine as it seldom rusts, oh and 3 mtrs for each run is loads, Rick

solarman216 · 07-09-2014, 19:32

Quote:

Originally Posted by AlexD333

All be it brief, I have quickly skipped through this and lots of talk about vents for fuel, I have to leave my fuel cap open a smidge otherwise it makes a vacuum

HISSSSS when you open it

it is supposed to Alex, Rick

AlexD333 · 07-09-2014, 21:42

Quote:

Originally Posted by solarman216

it is supposed to Alex, Rick

Even when half full ect?

It was the typical empty symptom, only started after I switched to veggie, I suspected a blockage of a breather or some such

solarman216 · 07-09-2014, 21:55

Quote:

Originally Posted by AlexD333

Even when half full ect?

It was the typical empty symptom, only started after I switched to veggie, I suspected a blockage of a breather or some such

All terrano's have a tank recirculating breather system that burns the fumes from the tank there are a host of valves that control this, Rick

AlexD333 · 07-09-2014, 21:57

Quote:

Originally Posted by solarman216

All terrano's have a tank recirculating breather system that burns the fumes from the tank there are a host of valves that control this, Rick

Whoops, so does this mean I have been screwing with my recirc system by keeping the cap backed off half a turn?

solarman216 · 07-09-2014, 22:06

Quote:

Originally Posted by AlexD333

Whoops, so does this mean I have been screwing with my recirc system by keeping the cap backed off half a turn?

yep you have been polluting the air with your veg/whatever fumes, Rick

AlexD333 · 07-09-2014, 22:13

Quote:

Originally Posted by solarman216

yep you have been polluting the air with your veg/whatever fumes, Rick

I know my fuel pump leaks but me and the missus recently have been commenting in how bad the terrano stinks when we get close to her (engine off!)

07-09-2014, 19:15	#16
solarman216 Off road maniac Join Date: Dec 2009 Location: Bexhill on Sea Vehicle: Y60 Patrol Me, 3 ltr Mrs Posts: 17,431	filler caps have not had vents for years the tank fumes are redirected back into the engine to be burnt often through a charcoal filter, Rick __________________ Ex banger racer now off road maniac Lokka on the front with manual hubs Diff lock on rear 3 inch SS straight through exhaust Manly winch bumper with 13000 lb winch 10 spike ground anchor, with multiple straps and blocks Super strong body cills capped with scaffold pole 20% stronger springs all round aggressive off road tyres on wheels so just swap. Aim to get stuck and be completely self sufficient in extraction, love getting muddy, 2ft deep is good but rare.

07-09-2014, 19:20	#17
AlexD333 Senior Member Join Date: Jan 2014 Location: Uk Vehicle: 2004 Terrano 2.7 TDI Posts: 7,847	All be it brief, I have quickly skipped through this and lots of talk about vents for fuel, I have to leave my fuel cap open a smidge otherwise it makes a vacuum HISSSSS when you open it